三维电极电Fenton氧化法处理染料废水

采用三维电极电Fenton氧化法处理实际染料废水,探究了染料废水处理效果的影响因素。实验结果表明：以钌铱镀层钛电极为阳极、不锈钢板为阴极、粉末活性炭为颗粒电极,在粉末活性炭投加量为2.0 g/L、电流密度为0.5 mA/mm²、极板间距为3 cm、pH为2.0、硫酸亚铁投加量为0.50 g/L的最优工艺条件下,反应2 h后COD、TOC、氨氮、色度的去除率达到最大,分别为62.80%、41.15%、42.48%和95.00%;粉末活性炭作为颗粒电极可使染料废水COD去除率提高18个百分点;重复使用10次的处理效果与第2次基本持平。     

Investigating the quantitative and qualitative status of effluent in the wastewater treatment plant in Iran Central Iron Ore

The aim of present study was to investigate the quality of the produced effluent from different units of the Iran Central Iron Ore in Bafq city and comparison of effluent with the standards. This study presents the physicochemical and biological parameters data of effluent of three Sequencing batch reactors (SBR) with a capacity of 160 m³?d^?1. Most common parameters include pH, total suspended solids (TSS), total nitrogen (TN), total phosphorus (TP), biochemical oxygen demand (BOD₅), chemical oxygen demand (COD), heavy metals, and total coliforms and fecal coliforms as biological indicators. Then, for each SBR system, the average of each parameter was determined, and results were compared with the standard recommended by the Iranian Environmental Protection Agency. Based on the results, some of the parameters, including BOD₅, COD, and TSS in the wastewater treatment plant (WWTP) effluent, are higher than the permitted amount for discharge to the surface water. Considering the BOD₅, COD, and TSS concentration in WWTPs, the treated wastewater is only suitable for agricultural and irrigation use. Therefore, wastewater produced by Iran Central Iron Ore Co. will need additional treatment to achieve standard quality of water before discharge in surface water and adsorbent well.     

UASB-SBR组合工艺处理畜禽养殖废水的研究

近年来,随着中国畜禽养殖业的快速发展,落后的养殖模式和污染防治设施,使畜禽养殖污染日趋严重,畜禽养殖污染已居农业污染源之首,已成为中国环境污染的重要因素,对环境质量乃至人体健康都会产生不良影响。文中采用UASB—SBR组合工艺处理畜禽养殖废水,通过试验探讨SBR反应器启动方法及最佳运行模式,同时研究UASB反应器的启动方法。结果表明,SBR运行的最佳模式为进水0.5 h、反应8 h、沉淀1 h、出水0.5 h、闲置14 h。经过一段时间的启动,UASB和SBR反应器均成功启动,UASB—SBR组合工艺在处理畜禽养殖废水时可获得稳定的处理效果,COD、氨氮、总磷等出水水质均达到《畜禽养殖业污染物排放标准》(GB18596-2001)要求,为畜禽养殖废水处理的工程化应用提供了参考依据。     

甜菜制糖生产废水提标改造设计分析

食品废水处理对我国的经济发展以及环境业提高具有重要的推动作用。本文以某制糖厂为例,对甜菜制糖废水处理站的提标改造工程进行详细分析,在此基础上进行合理设计。     

采油作业“三废”控制技术研究与应用

针对采油作业产生的废酸、固废、废水处理成本高、技术不成熟等问题,研发改性废酸降压增注、深部调剖技术;高比重污泥悬浮研磨后的固废处理技术;低耗水打塞、原井液+CaCl2压井、原井液处理再利用技术,减少了"三废"的产生,解决了"三废"环保处理费高等问题,消除了环保隐患,实现了清洁生产,环境效益显著。     

污水处理厂设备维护管理优化研究

以JL污水处理厂设备管理优化过程为例,充分吸取LCC,TPM中的先进思想,以设备运行可靠性及设备维护经济性为追求目标,建立了设备管理优化体系。流程体系上,通过建立作业指导文件,建立标准化维修程序,对于操作过程及时进行记录,建立可视化、可追溯的管理方法;指标体系上,根据设备重要性及运行状况,确定设备风险指数,分级管理;建立控制指标,并动态调整;管控体系上,建立设备“户口”,对设备的维护、保养、使用等信息进行全面登记;考核设备维护的全面性、及时性、可靠性、合规性;重视设备维护的预计与预警;技术体系上,通过设备监测仪器的使用,对设备运行状况定量化。通过不断推进设备预防性维护工作,设备完好率不断提升,仪表完好率从2016年的97.34%,96.55%水平,分别提升至99.08%,98.72%;维护费用也保持在较低水平,检修费与资产比例在实施的前两年分别降至1.49%,0.85%,实现了污水处理厂节能降耗及运行可靠性的强化。     

The formation of aerobic granular sludge for the treatment of real landfill leachate using a granular sequencing batch reactor at a constant volume

Leachate generated in a landfill may not be treated by conventional biological treatment due to its nature and complexity. The process of forming aerobic granules in batch sequencing reactors having features such as; reducing the settling process time and saving energy consumption and high decomposition rate have been noticed by researchers. In the present study, the structure of sequencing batch reactors (SBRs) was evaluated for the formation of granules, which were subsequently utilized for the treatment of landfill leachate. The experiment was initiated by using the GSBR, containing 1200 ml with different apparatuses, to develop granular sludge, and synthetic wastewater was added to reinforcement. The selected parameters for the operational hydraulic retention time (HRT) of the wastewater (6-h cycles) included feeding, idle, aeration, settling, and discharge. Furthermore, the controlled conditions were the dissolved oxygen (DO) range of 2–2.2 mg/L, temperature range of 20–23℃, and pH of 7.5–8.3. The chemical oxygen demand (COD), mixed liquor suspended solids (MLSS), and sludge volume index (SVI) daily were measured at the influent and effluent of GSBR reactor. The main properties of aerobic granular sludge were identified during the research procedures, and the remarkable settling and potent, high-density microbial structure of the granules were confirmed. The mean size of the formulated granules was estimated at 7.46 ± 1.8 mm, and the volume of the biomass also increased from approximately 1607 to 4137 mg/L through the granulation process. Moreover, 98% of the influent chemical oxygen demand (COD) could be removed by the formulated granular sludge, and the final-stage organic loading rate was estimated at 5.65 COD/m³/day. According to the results, GSBRs could be employed for the formulation of aerobic granular sludge for the treatment of landfill leachate.     

城市污水再生处理工艺中发光细菌毒性变化的初步研究

保障再生水的生态安全是污水再生利用过程中非常关键的问题.本文采用发光细菌毒性测试方法测定了2个城市污水再生利用示范工程工艺流程中生物毒性的变化,尤其是可能生成有毒副产物的氯消毒过程中的毒性变化.结果表明,二级生物处理能显著降低污水的发光细菌毒性,但氯消毒显著提高了污水的毒性,并且脱氯后污水的毒性仍保持较高的水平,对生态安全造成了潜在威胁.同时,通过比较2种污水水质发现,DOC(溶解性有机碳含量)和UV254(254 nm处的紫外吸收值)较高的水样,消毒后的毒性较大,认为DOC和UV254可望作为预测污水消毒生态风险的水质指标,为污水消毒实践中确定安全合理的污水水质条件提供一定的依据.     

絮凝剂聚硅酸锌铁(PZFSiC)的研制和性能

在高模数水玻璃溶液中加入酸制备出聚硅酸,再引入适量的金属离子M(Zn、Fe),研制出一种新型的无毒无机复合高分子絮凝剂聚硅酸锌铁(PZFSiC).探讨了M与SiO2不同浓度比和不同pH值对PZFSiC的絮凝效果的影响,通过正交实验找出了最佳的制备工艺条件.在此基础上,进一步对两种不同的水样进行了絮凝实验,确定出水处理中最佳絮凝工艺条件.结果表明,PZFSiC具有较好的贮存稳定性,在使用PZFSiC时,适应的pH范围广.在实验过程中形成大而致密的絮体,沉降迅速,浑浊度去除率超过98%,COD去除率达93%.处理后的废水,出水水质好,水样澄清透明.在与同类絮凝剂对比实验中,效果优于PZSiC和PFSiC.     

污水灌溉对土壤重金属含量、酶活性和微生物类群分布的影响

以沈阳张士灌区长期污灌的农田土壤为对象,研究了土壤重金属、土壤酶活性、微生物生物量和种群分布特征,分析了土壤微生物参数与土壤重金属和土壤性质的相关关系.结果表明,虽然已停止污灌十余年,张士灌区农田土壤仍存在Cd、Zn、Cu等多种重金属污染.土壤Cd污染最严重,含量达1.75～3.89 mg·kg-1.土壤耕作层(0～30cm)Zn、Cu、Pb总含量随土层深度增加逐渐减少,而Cd元素的垂直分布呈向下迁移的趋势.Cd、Zn、Cu、Pb等4种重金属含量水平分布特征相似,均为1号样地＞2号样地＞3号样地＞4号样地.相关性分析表明,张士灌区土壤酶活性、微生物生物量和种群分布受重金属污染和土壤养分的影响,土壤养分含量(有机碳、N、P、K)对微生物的正面效应大于重金属对微生物的负面效应.土壤全量Cd和速效K对微生物参数的影响最为明显,Cd含量与多酚氧化酶活性和微生物生物量(Cmic)呈极显著负相关,与纤维素酶活性呈极显著正相关(P＜0 01),速效K含量与多酚氧化酶活性、微生物生物量以及可培养微生物种群数量均呈极显著正相关(P＜0.01).